journal paper on copper slag as a sand

An Experimental Study on Partial Eplacement of Cement by ...

parameters of the concrete. So I am using copper slag as a one of the constituent alternative material for sand in concrete about 50% by weight of sand. For my project I collected the copper slag JSW jindal, Hospet. Figure 2: Copper Slag.

Get More

INVESTIGATION ON USE OF COPPER SLAG AS PARTIAL …

This project reports on an experimental program to investigate the effect of using copper slag as a replacement of fine aggregate on the strength properties. ... For this research work, M50 grade concrete was used and tests were conducted for various proportions of copper slag replacement with sand of 0, 20%, 40%, 60%, 80% & in concrete ...

Get More

Study on Strength Properties of Concrete with Admixture ...

The test results were obtained for M30 mix by adding copper slag to sand in various percentages ranging from 0%, 20%, 40%, 60%, 80% & at 10% iron slag as a replacement with cement in concrete which is approved by Indian Standards.

Get More

Effects of Copper Slag as Partial Replacement for Fine ...

From different studies carried out by the partial replacement of fine aggregate with copper slag in geopolymer concrete, the range of 50% of copper slag is found possible without much reduction in compressive strength. This paper presents an experimental study on the effects of copper slag …

Get More

Experimental Study on Concrete by Replacement of Fine ...

Experimental Study on Concrete by Replacement of Fine Aggregate with Copper Slag, GGBS and M- Sand 245.26 KB

Get More

INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL …

INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL ENGINEERING ... INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL ENGINEERING Volume 1, No 4, 2011 ... Studies by Alnuaimi (8) indicated that replacement of fine aggregate (sand) by copper slag ...

Get More

Experimental Investigation on the Mechanical Properties of ...

International Journal of Current Engineering and Technology E-ISSN 2277 – 4106, P-ISSN 2347 ... copper slag as sand replacement yielded comparable strength with that of the control mix (Al-Jabri et. al., 2009). Chavan et. al., investigated the effect of using copper slag …

Get More

Research Paper EFFECTS OF SUSTAINABLE MATERIALS AS …

Copper slag as partial replacement for sand at 25, 50 and 75% was used. The dosage of Super plasticizer used in this experimental investigation was 0.75% by the weight of …

Get More

INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL …

INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL ENGINEERING ... INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL ENGINEERING Volume 1, No 4, 2011 ... Studies by Alnuaimi (8) indicated that replacement of fine aggregate (sand) by copper slag ...

Get More

INTERN ATIONAL JOURNAL OF CIVIL ENGINEERING …

alternative replacement material of sand. This paper also studies the effect of replacement of Fine aggregate with copper slag on mechanical properties of concrete. KEY WORDS: Copper Slag, Concrete, Properties, Durability, Sand Replacement 1.1 INTRODUCTION Protecting the depleting natural sand resource and the shore line is a major concern of the

Get More

The Behaviour of Concrete by Partial ... - IOSR Journals

GGBS in concrete mix. In this study, partial replacement of Cement with GGBS and Sand with Copper Slag considered. Experimental study is conducted to evaluate the workability and strength characteristics of hardened concrete, properties of concrete have been assessed by partially replacing cement with GGBS, and sand with Copper Slag.

Get More

Properties of pavement quality concrete and dry lean ...

The work reported in this paper is based on a laboratory study carried out to investigate the feasibility of using copper slag, a by-product of copper refineries, as a partial replacement of sand in the preparation of pavement quality concrete (PQC) and dry lean concrete (DLC) mixes.

Get More

A REVIEW OF INNOVATIVE USE OF COPPER SLAG AND …

concrete. This paper deals with the review of literature for copper slag and foundry sand as partial replacement of fine aggregates in concrete. KEYWORDS: Concrete, Cement, Sand Replacement, Copper Slag and Foundry Sand INTRODUCTION In India, there is great demand of aggregates mainly from civil engineering industry, for

Get More

Research Paper PERFORMANCE OF COPPER SLAG ON …

This paper reports on an experimental program to investigate the effect of using copper slag as a replacement of fine aggregate on the strength properties. Copper slag is the waste material of matte smelting and refining of copper such that

Get More

Effects of Copper Slag as Sand Replacement in Concrete

determine the fineness modulus of copper slag, sand and coarse aggregate. The specific gravity of sand and copper slag was 2.67 & 2.75 respectively as shown in Table 2.1. The water absorption of 20 mm coarse aggregates, sand &copper slag was found to …

Get More

International Journal of Computer Sciences and Engineering

This research paper presents a study of the Strength properties of concrete by partial replacement of fine aggregate with copper slag and cement with silica fume. In the present Experimental Investigation, for M40 grade of concrete, fine aggregate (River Sand) was partially replaced with Copper Slag (40%) and cement was partially replaced with ...

Get More

AN EXPERIMENTAL INVESTIGATION ON STRENGTH ... - ARPN …

ARPN Journal of Engineering and Applied Sciences © 2015 Asian Research Publishing Network (ARPN). ... This paper presents a study of the mechanical properties of copper slag fibre reinforced concrete considering the ... sand with copper slag. The strength was found to

Get More

Investigation on Copper Slag Enriched FaL-G Mortar Bricks

This paper is deals with the investigation on Copper slag enriched FaL-G mortar blocks by partial or full replacement ... was reduced with up to 40% copper slag replacement for sand. The volume of permeable voids decreased with the ... International Journal of …

Get More

Studies on use of Copper Slag as Replacement Material for ...

• The percentage of copper slag used for replacement of river sand are 0, 25, 50 and 75 % • Cement sand mortar joint thickness of 10 and 15 mm • Plaster ability of use of copper slag for partial replacement material for river sand • Use of copper slag as replacement material for river sand in cement concrete (0, 25, 50, 75 and 100 % ...

Get More

An Experimental Study on Partial Eplacement of Cement by ...

International Journal of Latest Engineering Research and Applications (IJLERA) ISSN: 7137 ... to overcome this usage of these materials will reduce the environmental pollution along with instead of sand we are using copper slag and quarry dust in concrete about 50% of copper slag and 50% of quarry dust is used and ... In this paper ...

Get More

indian journals on slag sand

Journal of The Institution of Engineers (India): Series A ... different proportions of copper slag and sand were tested for use as masonry mortars... Read more Use of furnace slag and welding slag as replacement for sand in ...

Get More

Performance of Copper Slag and Foundry Sand in Concrete

R,Performance of Copper slag and ferrous slag as partial replacement of sand in Concrete.(INTERNATIONAL JOURNAL OF CIVIL AND STRUCTURAL ENGINEERING Volume 1, No 4, 2011) [3] AS Alnuaimi Department ...

Get More

Copper Slag Blended Cement: An Environmental Sustainable ...

Indian cement industry is facing environmental issue of emission of carbon dioxide (CO 2), a greenhouse gas.Blended cements including supplementary cementitious materials are substitute of Portland cement to reduce CO 2 emission. The present paper investigates theappropriateness of copper slag (CS) as supplementary cementitious material.

Get More

An Experimental Investigation on Optimum Usage of Copper ...

a partial replacement of sand with copper slag. The sand was replaced from a minimum of 0% to a maximum of 50% with copper slag. A total of five combinations were studied for M20 concrete mix. Sand was Partial replaced with copper slag in proportions of 0%, 10%, 20%, 30%, 40% & 50%. The Compressive Strength was calculated at

Get More

Copper slag: optimization of productivity and consumption ...

Copper slag, a by-product from copper smelting industry, is widely used as an abrasive material to remove rust, old coating and other contamination in dry abrasive blasting which is an expensive process and results in significant amounts of particulate emissions and spent abrasive.

Get More

Effect of Lime and Cement on the Strength Improvement of ...

International Journal of Engineering Trends and Technology ... during the matte smelting and refining of copper. It is currently being used for sand blasting, rail road ... stabilization of Black Cotton soils using Copper Slag. In this paper, the improvement in strength of

Get More

Strength and durability characteristics of conventional ...

Some of the journals referred for this project and present ... copper slag replacing sand up to 50% were used to study the strength parameters, compressive strength, split ... 5.6 Physical Properties of copper slag: The slag which is used in this paper is a black glassy and

Get More

A Mix Design of Self Compacting Concrete with Copper slag ...

of river sand. Copper slag is one of the waste materials that are obtained from copper manufacturing industry. This material is suitable for fine aggregate. Hence it is a waste materials and is eco friendly. European Federation of National Associations Repre-senting for …

Get More

Performance of Copper Slag and Foundry Sand in ... -

The paper reviews the utilization of Copper slag and foundry sand as the concrete constituent and the noticeable and important findings from the experimental works of various researchers.

Get More

Copper slag as sand replacement for high performance ...

This paper reports on an experimental program to investigate the effect of using copper slag as a replacement of sand on the properties of high performance concrete (HPC).

Get More

Effect of Copper Slag as a Partial Replacement of Fine ...

Copper slag is one of the materials that is considered as a industrial waste which can be used in construction Industry. This paper presents the results of an experimental investigation on the properties of concrete using copper slag as partial replacement of fine aggregate.

Get More

Evaluation on Accelerated Corrosion Properties of the ...

Then copper slag is replaced by 20 %, 40 %, 60 %, 80 % and 100 % of sand simultaneously with mineral admixture i.e., 5% to 30% of cement in the increment of 5 percent to study compressive strength, density, split

Get More

Utilization of copper slag in cement and concrete ...

The use of copper slag in cement and concrete provides potential environmental as well as economic benefits for all related industries, particularly in areas where a considerable amount of copper slag is produced. This paper reviews the characteristics of copper slag and its effects on the properties of cement, mortars and concrete. 2.

Get More

Copper Slag As Fine Aggregate For High Performance Concrete

This paper presents results from an experimental investigation carried out to study the potential use of copper slag as fine aggregate on the strength of both normal and high strength concrete. Concrete mixtures were prepared using different proportions of copper slag as …

Get More

journal paper on copper slag as a sand

journal paper on copper slag as a sand Copper Slag As Fine Aggregate For High Performance … This paper presents results from an experimental investigation carried out to study the potential use of copper slag as fine aggregate on the...

Get More

International Journal of Research

With the end goal to decrease the collection of copper slag and furthermore to give an elective material to sand and cement a methodology has been done to explore the utilization of copper slag in cement for the partial replacement of sand and cement.

Get More

Use of waste copper slag, a sustainable material | Request PDF

The root permeated copper slag mixed soil is a effective way to reinforce soft soil and dispose the copper slag. In order to better investigate the strength rule of it, firstly, a new shear test ...

Get More

Experimental Investigation on Split Tensile and ...

This paper mainly presents the practical study of the compressive strength and tensile strength of the concrete. In this study, M25grade concrete was used and tests were conducted for different mix proportions of sea sand and copper slag. The obtained results were compared with those of control concrete made with river sand.

Get More

Copper slag as sand replacement for high performance ...

This paper reports on an experimental program to investigate the effect of using copper slag as a replacement of sand on the properties of high performance concrete (HPC).

Get More

Slag Admixed Concrete - Integrated Publish

2.3 Copper Slag Copper slag from Sterlite Industries India Limited (SIIL), Tuticorin, Tamil Nadu, India was made use of. 2.4 Physical and Chemical properties of copper slag The slag is a black glassy particle and granular in nature and has a similar particle size range like sand.

Get More